Category Archives: 2006 TD5 90

A 2017 Update

Leave a reply

Well as the blog hasn’t been updated in a while, I thought I would take some time and post an update.

Jordan

1966 Series 2:

The car was sold the tail end of 2016 as an unfinished project.  progress stalled on the car and never really got going again.

2006 Disco 3

The car is still going, recently had a handbrake module replaced.  Another repair carried out by land rover was to resolve a recall issue of oil in the brake system.  This had already been done once but the issue re occurred, so they eventually sorted it again.

Disco 2

Since selling the Series 2 Jordan has also purchased a Disco 2 4 ltr V8.  Initially it was sold as the previous owner had put diesel in the tank and tried to start it so some basic work was carried out the car is now taxed and tested and back on the road.

Ian

1983 Ninety

Following a change of job and moving away in May 2016 I don’t have day to day involvement with my car any more, but it is still going driven by my dad on a daily basis.

At the end of October 2016 we made a small addition to the car to allow us to sleep inside it while going to watch Wales Rally GB, this involved some support bars and sheets of marine ply.  Made for a very handy night out kept out of the elements, will post some photos of this later.

Other issues at the moment with the car is the Wipac LED side lights keep blowing fuses up to 15A so more investigation is required.

Nick

1986 110

No change on this yet the car is still as it was when picked up.

Disco 1

Still owned but currently not used.

2001 Disco 2

The car previously owned by Jordan is now mainly used for spare parts.

Disco 2

A TD5 Auto car which has some off road modifications such as tyres bumpers, LED light bar.

Kelsey & Pete

2006 90 TD5

Kelsey and Pete still use this car, recent additions of some 5 bar tread plate, apart from that the car is mostly used on road.

Tom

1993 90 300TDi

Following the rebuild not heard of any more issues with the car, still see it driving around.

Matthew

People are told, if you can’t say anything nice about a person, don’t say anything…

Advertisement

Daisy Pains

Leave a reply

Well another quick update, recently we have had a couple of little issues with Daisy the TD5 90, it all started with a bit of wet weather, when trying to drive the engine warning light came on and throttle response stopped.

After using diagnostics the fault showed up in the computer as Driver Demand, after a bit of looking we thought it was the EGR valve, a bit of inspection showed that it was a bit clogged so we fitted an egr blanking kit.  that seemed to do the trick for a little while.

Then a couple of weeks later the same issue happend again! unimpressed we decided to go to the next possible cause the accelerator pedal, we had purchased one off ebay at the same time as the EGR valve so put it back in and the fault remained the same.

We noticed that the fault was caused when pressing the clutch, so replacement of the switch on the clutch pedal with MSK100050 [MSK500010] seems to have sorted the issues for now.

A long needed update

Leave a reply

Well things have been a bit manic recently so updates were last thing on the mind.

But alas here we are April 2015 and here is an update on how things are going.

Ian’s Car – 200tdi 90

Well 12 months since the rebuild finished, its MOT time again.  Car went in for its test Tuesday 7th April.  It failed 😦  The issues were headlights weren’t bright enough, the drivers door wouldn’t open from inside the car.

So all in all not too bad, but the worst item was down as an advisory but actually caused the end of the test.  A UJ in the rear prop had failed to the point where the tester wasn’t willing to carry out deceleration tests.  The prop was unbolted and the UJ’s purchased and replaced.  the prop then bolted back on and boy did it make a difference.

The door not opening was a case of adjustments on the mechanism for the handles just shortened them a bit and opening now much easier.

The headlights were the biggest concern.  As I have high performance bulbs fitted to the car when the tester said they didn’t register on the testing machine.  So reading around the subject points at a burnt out light switch causing poor performance.  The solution is to put a relay feed to the lights.  I purchased a Red Bison Boomslang from Paddockspares for £30 it was a bargain for the entire kit.  I had it fitted in no time and made a massive improvement, its a product I would recommend to anyone.

MOT Retest 18 April 1pm.  Result: Car passed

Jordan’s Series II

Well not much work has been done on the car since November, panels are now painted but not yet fitted to the car.  The accelerator has now been refitted and the car can be driven around.

The main reasons for this is we have been busy working on Jordan’s Discovery 2, which since november has had a number of coolant hoses as it has been loosing coolant and the pressure build up has popped them.  We have now replaced the suspected cause of the coolant loss and so far so good.

Nick’s Discovery

It has been plodding along as normal.  We had a bit of fun while jet washing it ready for MOT when the jet wash smashed the sun roof.  so that has been replaced and the alpine windows have been taken out and covered over.

Matthews Series.

As Matthew has decided he isn’t friends with 2 / 3 of us working on Land Rovers there will be no further updates about his car as we dont see him any more.

New Cars:

Yes we have been joined by two more land rovers that we can enjoy working on.

Daisy The Defender is a 2006 TD5 90, owned by some friends we have had a little bit of work to do on the car already including replacing a failed fuel pump and then adding some new bits such as chequer plate wing tops and a new bumper.  With being such a new car there shouldnt be that much to do on it for now.

Tom’s 300tdi 90, this is going to be our next big project, Toms car is in need of a new chassis, due to the amount of rust it has, we could go down the route of repair pieces but Tom fancies doing a chassis, so one has been ordered so big project ahead for the summer.  There should be plenty of updates on this one.